NH90 Caribbean Loss of Control – Inflight, Water Impact and Survivability Issues

NH90 Caribbean Loss of Control – Inflight, Water Impact and Survivability Issues 

On 19 July 2020, a Royal Netherlands Navy NHIndustries NH90 NATO Frigate Helicopter (NFHN-324 was destroyed in a water impact in the Caribbean near HMNLS Groningen.

Two of the four crew died.  The aircraft, which capsized and initially floated inverted, sank the next day after the forward flotation bags deflated.

The Dutch Safety Board (DSB or Onderzoeksraad) issued a report (in Dutch only) on 9 December 2020.  This followed an ‘exploratory investigation’ and the Defence Safety Inspectorate (IVD) are expected to investigate further (UPDATE 2 December 2021: that follow-on report is now published and discussed below).

Rescuers Alongside the Royal Netherlands Navy NH90 N-324 in the Caribbean (Credit: RNLN)

Rescuers Alongside the Royal Netherlands Navy NH90 N-324 in the Caribbean (Credit: RNLN)

The Accident Flight

Holland-class offshore patrol vessel HMNLS Groningen was deployed to the Caribbean.

The ship’s embarked NH90 had conducted a routine patrol flight around Aruba on 19 July 2020 and was undertaking a series of deck landings to keep the ship’s flight deck officer current. The NH90 is flown operationally single pilot in the Netherlands.  The front left seat is occupied by the tactical coordinator, in the cabin there are the hoist and sensor operators.  The pilot had 1679 hours of helicopter flight experience, 719 hours on type (306 hours as aircraft commander) plus 310 hours of NH90 time simulator.

An NH90 Operating on the helideck of a Warship of the Royal Netherlands Navy (Credit: NL Ministry of Defence)

An NH90 Operating on the helideck of a Warship of the Royal Netherlands Navy (Credit: NL Ministry of Defence)

The deck practices were conducted in a standard way.  After coming into a hover from the ship’s deck, the helicopter moved sideways to the left and then climbed away. On return the helicopter approach the ship from behind, came into a hover on the right side of the flight deck, and then moved sideways and landed. The ship was steaming at just 3 knots in a direction of 108º and the wind was from 100º and 20-25 knots.  The waves were 3 m high, the air temperature 31ºC and the sea temperature 29ºC.

On the eighth practice flight did a lower circuit than before, less than 100 ft, as the plan was to take photos of the ship. As the helicopter passed down the right-hand side of the ship downwind…

…the aircraft suddenly lost altitude very quickly and ended up in the sea with a bang. On impact, the tail broke off and the aircraft capsized, flooding the cabin. As a result of the impact, fuel immediately released around the aircraft. The floats automatically inflated and the helicopter continued to float upside down.

Royal Netherlands Navy NH90 N-324 Floating Inverted in the Caribbean (Credit: RNLN)

Royal Netherlands Navy NH90 N-324 Floating Inverted in the Caribbean (Credit: RNLN)

The ship dispatched a fast rescue craft.

The wreckage was located 2-9 August 2020 450 m below the surface.  Salvage then occurred 7-8 September 2020 using multi-role subsea construction vessel Volantis of  Deepwater, a DeepOcean Installer Remotely Operated Vehicle (ROV) NS a lifting cradle.

Salvage Using Deepwater's Volantis (Credit: MOD NL)

Salvage Using Deepwater’s Volantis (Credit: MOD NL)

Safety Investigation: Egress, Survivability and Rescue

All the crew had done Helicopter Underwater Escape Training (HUET) in Den Helder.

HUET video

The sensor operator, who was sat on a box in the cabin was thrown forwards.  The hoist operator was able to brace against the gun mount by the right-hand cabin door.  Both were connected to the aircraft by a safety line.  The immediate capsize resulted in disorientation.  Having attempted but failed to open an exit they egressed via a push out window without injury.  However, there were Aircrew Equipment Assembly (AEA) issues:

Both men wore a personal vest of a type that had recently been introduced, but with which they had not yet trained. Using the new vests caused problems for the two men.

There is a quick release a mechanism for disconnecting the safety line, to prevent falling from aircraft with the door open. Both crew members were unable to open the buckle on the front of the vest, forcing them to disconnect the hook from the cabin wall. This wasted valuable time.

Another problem was that the position of the compressed air [emergency breathing system or Short Term Air Supply System (STASS)] bottle has changed from right to left compared to the old vest.

The DSB note that their survival indicates the impact “took place at a relatively low vertical speed.”

The pilot and tactical coordinator “suffered minor external injuries, but that there was no high-energy injury that was life-threatening”.  Both drowned.

The pilot succeeded in exiting the aircraft but was found unconscious underwater outside the aircraft. She was entangled with a connecting line to the one-person life raft in her seat, which appears to have become snagged.

Pilot Raft Seat Pack and Connecting Line (Credit: DSB)

Pilot Raft Seat Pack and Connecting Line (Credit: DSB)

The raft itself had inflated.  Her body was freed after about 25 minutes.

Pilot's Inflated Individual Life Raft (Credit: RNLN)

Pilot’s Inflated Individual Life Raft (Credit: RNLN)

The tactical coordinator was found by rescuers trapped in his seat with his life jacket inflated about 50 minutes after the accident.  The DSB don’t comment but it’s possible the tactical coordinator inflated his life jacket inadvertently while instinctively searching for the STASS bottle on the opposite side to its actual location.

The Holland-class OPVs are operated with a modular crew concept in which the size and composition of the crew depends on the ship’s tasking.

Because of this organizational form, crew members had to make choices during the rescue operation between different roles to be performed. These choices did not affect the deployment, but did require quick situational decisions in making the choices.

The DSB do query if the crew had been constituted appropriately for this deployment.

Safety Investigation: The Dynamics of the Flight

The aircraft was equipped with a Recorder Beacon Airfoil (RBA) which acts as an Automatically Deployable Emergency Locator Transmitter (ADELT) and holds a Voice and Flight Data Recorder (VFDR) memory unit.

nh90 aruba n324 rba

It detached as designed, its signal was received by the Netherlands Coast Guard at Den Helder, and was recovered the next day.

The data was analysed and no technical anomalies were identified with the aircraft, nor were there any issues found in the aircraft records.  The recovered data also showed that during the first seven circuits, the helicopter flew at an average altitude of approximately 150 ft. The sixth circuit featured a wider circuit and reached 400 ft.

nh90 aruba n324 radalt 8 runs

On the last (eighth) practice run, the aircraft did not climb higher than approximately 89 ft. On this run the speeds were, Ground Speed (GS) and Indicated Airspeed (IAS) were significantly lower than during the previous flights.

nh90 aruba n324 airspeed 8 runs

The aircraft turned right, across the path of the ship to pass along the ship’s starboard side, downwind.

Final Circuit of HN90 N-324 (Source IVD)

Final Circuit of HN90 N-324 (Source IVD)

The GS was only about 25 knots so the IAS dropped to zero…

…this situation requires a lot of power. It was determined that the selected power – given the airspeed at that moment – was not sufficient to keep the helicopter at altitude. As a result, the helicopter slowly lost altitude initially…and then very quickly changed into an accelerated descent.

nh90 aruba n324 power ias

See also: Understanding Helicopter Power Requirements: The Power Struggle

The pilot did react to try to reduce the descent but the low altitude prevented that being successful.

DSB Conclusions

The water impact occurred after airspeed reduced during the downwind leg with insufficient power input at a height that prevented recovery (a Loss of Control-Inflight [LOC-I]).

The egress of the rear crew was “seriously hindered” by the inability to open the harness quick release mechanism and the different position of the STASS bottle which they had never been trained on.

Neither the pilot nor the tactical coordinator suffered an impact injury that would have precluded egress but both were unable to escape.

“…crew members of HNLMS Groningen tried to save the helicopter crew with maximum effort. Nevertheless, the question remains…with regard to crew size, composition and role system to be able to carry out such a rescue operation. It is certain that they had insufficient resources for this as divers were lacking”.

DSB Follow-Up Questions

The DSB posed a number of questions to the Ministry of Defence in their report:

  1. To what extent are the education and training courses and the use of materials by crews of the NH90 helicopter realistic and sufficient?
  2. To what extent are pilots sufficiently educated and / or trained to ensure that they do not end up in a similar [LOC-I] situation?
  3. To what extent are the education and training and the use of materials of the ship’s crew realistic and sufficient for carrying out rescue operations, such as an air crash or the sinking of a nearby ship?
  4. To what extent has the assessment of safety risks in multitasking been included in the choice for a single pilot?
  5. To what extent would a second pilot provide redundancy in the performance of tasks and can that make the difference in a comparable situation?
  6. To what extent has the choice of balancing safety risks in rescue operations been included in the modular crew concept?
  7. To what extent has a risk assessment (on preparation of crew and resources on the station ship for the rescue of people from a crashed aircraft or ships in distress)  been made for the tasks in the Caribbean?

UPDATE 2 December 2021: Defence Safety Inspectorate (IVD) Report

The IVD published their investigation report (again in Dutch only) on 2 December 2021.  They confirm the DSB conclusions and make 5 new safety recommendations.

We will be updating this report and publishing a supplemental article during December.


We saw the DSB press release about the report on the morning it was issued and saved the file to translate and study in due course.  Special thanks to Graeme Longmuir for taking the initiative to translate the report and alerting us that the report contained some important safety equipment and training issues.  We therefore prioritised this case study.

RCAF Sikorsky CH-148 Cyclone (S-92) Ionian Sea, 29 April 2020

This was not the only loss of a maritime helicopter close to its parent ship this year.  The Royal Canadian Air Force (RCAF) lost Cyclone 148822 from the Halifax-class frigate HMCS Fredericton in the Ionian Sea at night on 29 April 2020.  The aircraft was destroyed and all six occupants were fatally injured.  The investigation is ongoing but it has been stated that:

…the aircrew were tasked as part of Operation REASSURANCE to conduct a routine surface reconnaissance mission in the Ionian Sea followed by flight deck evolutions for aircrew proficiency upon recovery to HMCS Fredericton. There were four crewmembers and two passengers on board the aircraft.

During the return for recovery, the aircraft made a pass on the port side of the ship,  from stern to bow. The aircraft then executed a left hand turn to establish a downwind leg in preparation for approach to the ship.  Astern and inside the control zone of the ship, the aircraft commenced a final left turn to set-up for the approach. During this final complex manoeuvring turn to close with the ship, the aircraft did not respond as the crew would have anticipated. This event occurred at a low altitude, was unrecoverable and the aircraft entered a high energy descent and impacted the water astern the ship.

The investigation is focusing on aircraft systems and human factors.

There was a temporary pause in Cyclone operation and when that was lifted it was stated that:

While the Directorate of Flight Safety investigation continues, information that the investigation uncovered to date —primarily from the Cyclone’s flight data recorder — allowed the investigative team to replicate the conditions in the CH-148 Cyclone flight simulator and rule out any mechanical failure. This revealed that the aircraft’s flight director was set to hold a specific altitude and airspeed. Thus, during the complex manoeuvering turn to align with the ship, the pilot’s inputs were significantly different from the autopilot settings and the aircraft [more specifically the AFCS flight control laws] did not respond in a way that the crew was expecting. The investigative team has confirmed that this rare anomaly only occurred under a very specific and narrow set of circumstances. The crew would have had no previous exposure or experience on how to handle this situation.

With these circumstances now clearly understood, the RCAF has completed a detailed risk assessment and is implementing mitigation measures to allow for the safe resumption of flying operations.

Safety Resources

The European Safety Promotion Network Rotorcraft (ESPN-R) has a helicopter safety discussion group on LinkedIn.  You may also find these Aerossurance articles of interest:

Aerossurance has extensive air safety, flight operations, SAR, airworthiness, human factors, survivability, aviation regulation and safety analysis experience.  For practical aviation advice you can trust, contact us at: enquiries@aerossurance.com